1887

Abstract

Summary

Water flooding is the most widely used intervention applied in the field. It started decades ago as a means to maintain the reservoir pressure by voidage replacement. Recently, it has been shown that the composition and the type of the water injected in the reservoir can have a significant impact on the interactions between water, oil, and reservoir rock. These interactions can impact the amount of oil recovery by water injection. Two widely used sources of water are high salinity water (HSW) and seawater (SW), especially for offshore reservoirs. High salinity water and seawater differ usually in terms of total salinity as well as composition of the dissolved ions and salts.

In this paper, we present the results of a set of coreflood experiments performed under reservoir conditions using two different crude oil samples in which we have compared the performance of conventional Seawater injection with that of HSW injection. A carbonate outcrop rock was used in the experiments. The coreflood data were also supplemented by advanced analysis of the produced oil and water samples in each experiment including interfacial tension measurements and brine composition analysis.

The results reveal that Seawater flooding improved oil recovery by 5% in secondary injection mode and by 3% in tertiary injection mode (enhancing oil recovery from 50% to 53%). Further investigation showed that this improvement was attributed to wettability alteration induced by SW injection.

This result is significant because it highlights the potential difference between injecting high salinity HSW and SW injection in terms of oil recovery factor. For the conditions of our experiments, seawater injection recovered considerably higher oil compared to HSW injection. The analysis of end-point relative permeability values obtained for seawater injection and for high salinity formation water indicate that the rock became more water-wet when seawater was injected compared to when HSW was injected.

The results demonstrate, for the first time, that seawater injection can be advantageous compared to high salinity water injection and highlights another factor to consider when designing a waterflood project. Seawater has been studied before for enhancing oil recovery but at much higher temperatures than our experiments.

© EAGE Publications BV
Loading

Article metrics loading...

/content/papers/10.3997/2214-4609.202531059
2025-04-02
2026-02-08

  • From This Site

    /content/papers/10.3997/2214-4609.202531059
    dcterms_title,dcterms_subject,pub_keyword
    -contentType:Journal -contentType:Contributor -contentType:Concept -contentType:Institution
    10
    5
Loading full text...

Full text loading...

References

  1. Al-Bayati, A., C. I.Karunarathne, A. S. AlJehani, A. Z.Al-Yaseri, A.Keshavarz and S.Iglauer (2022). “Wettability Alteration during Low-Salinity Water Flooding.” Energy & Fuels36(2): 871–879.
     [Google Scholar]
  2. AlHammadi, M., P.Mahzari and M.Sohrabi (2018). “Fundamental investigation of underlying mechanisms behind improved oil recovery by low salinity water injection in carbonate rocks.” Fuel220: 345–357.
     [Google Scholar]
  3. Alhammadi, M., S. M.Masalmeh, B.Al-Shehhi, M.Sohrabi and A.Farzaneh (2021). Experimental Investigation of the Impact of Crude Oil and Rock on Improved Recovery by Low Salinity Water Injection. SPE Annual Technical Conference and Exhibition?, SPE.
     [Google Scholar]
  4. Alotaibi, M. B., R.Nasralla and H. A.Nasr-El-Din (2010). Wettability challenges in carbonate reservoirs. SPE Improved Oil Recovery Conference?, SPE.
     [Google Scholar]
  5. Alwi, N., I. K.Salleh, J. Irvine-Fortescue, G.Graham, S.Dyer, R.Wright, C.Simpson, S.Kidd and R.Stalker (2013). Scale and scale inhibition challenges for an Alkaline Surfactant Polymer flood in a seawater flooded reservoir. SPE International Conference on Oilfield Chemistry?, SPE.
     [Google Scholar]
  6. Andreas, J., E.Hauser and W.Tucker (1938). “Boundary tension by pendant dropsl.” The Journal of Physical Chemistry42(8): 1001–1019.
     [Google Scholar]
  7. Austad, T., S. F.Shariatpanahi, S.Strand, H.Aksulu and T.Puntervold (2015). “Low salinity EOR effects in limestone reservoir cores containing anhydrite: a discussion of the chemical mechanism.” Energy & Fuels29(11): 6903–6911.
     [Google Scholar]
  8. Austad, T. and S.Strand (1996). “Chemical flooding of oil reservoirs 4. Effects of temperature and pressure on the middle phase solubilization parameters close to optimum flood conditions.” Colloids and Surfaces A: Physicochemical and Engineering Aspects108(2–3): 243–252.
     [Google Scholar]
  9. Austad, T., S.Strand, E.Høgnesen and P.Zhang (2005). Seawater as IOR fluid in fractured chalk. SPE International Conference on Oilfield Chemistry?, SPE.
     [Google Scholar]
  10. Aveyard, R. and S. M.Saleem (1976). “Interfacial tensions at alkane-aqueous electrolyte interfaces.” Journal of the Chemical Society, Faraday Transactions 1: Physical Chemistry in Condensed Phases72: 1609–1617.
     [Google Scholar]
  11. Badakshan, A. and P.Bakes (1990). “The influence of temperature and surfactant concentration on interfacial tension of saline water and hydrocarbon systems in relation to enhanced oil recovery by chemical flooding.”
     [Google Scholar]
  12. Bader, M. (2007). “Sulfate removal technologies for oil fields seawater injection operations.” Journal of Petroleum Science and Engineering55(1–2): 93–110.
     [Google Scholar]
  13. Bt Alwi, N., I. K. BtSalleh, J. M.Ibrahim, I.Carpenter, S. J.Dyer, C.Simpson, D. M.Frigo and G M.Graham (2016). Development of improved chemical formulations for scale control for alkaline surfactant polymer flood in a seawater flooded reservoir. SPE International Oilfield Scale Conference and Exhibition, SPE.
     [Google Scholar]
  14. Cai, B.-Y., J.-T.Yang and T.-M.Guo (1996). “Interfacial tension of hydrocarbon+ water/brine systems under high pressure.” Journal of chemical & engineering data41(3): 493–496.
     [Google Scholar]
  15. Chai, R., Y.Liu, Y.He, Q.Liu and L.Xue (2022). “Dynamic behaviors and mechanisms of fluid-fluid interaction in low salinity waterflooding of carbonate reservoirs.” Journal of Petroleum Science and Engineering208.
     [Google Scholar]
  16. Emadi, A. and M.Sohrabi (2013). Visual investigation of oil recovery by low salinity water injection: formation of water micro-dispersions and wettability alteration. SPE Annual Technical Conference and Exhibition?, SPE.
     [Google Scholar]
  17. Emadi, A. and M.Sohrabi (2013). Visual investigation of oil recovery by lowsalinity water injection: Formation of water micro-dispersions and wettabilityalteration. SPE Annual Technical Conference and Exhibition, Society of Petroleum Engineers.
     [Google Scholar]
  18. Facanha, J. M., P.Mahzari and M.Sohrabi (2017). Direct Observation of Low-Salinity Water Effect: Relationship Between Micro-Dispersion Formation and Wettability Alteration. SPE Middle East Oil & Gas Show and Conference, Society of Petroleum Engineers.
     [Google Scholar]
  19. Facanha, J. M. d. F. (2017). Fundamentals of wettability applied to Brazilian Pre-Salt reservoirs and wettability alteration evaluation in low salinity water injection, Heriot-Watt University.
     [Google Scholar]
  20. Farajzadeh, R., H.Guo, J. vanWinden and J.Bruining (2017). “Cation exchange in the presence of oil in porous media.” ACS Earth and Space Chemistry1(2): 101–112.
     [Google Scholar]
  21. Farhadi, H., S.Ayatollahi and M.Fatemi (2021). “The effect of brine salinity and oil components on dynamic IFT behavior of oil-brine during low salinity water flooding: Diffusion coefficient, EDL establishment time, and IFT reduction rate.” Journal of Petroleum Science and Engineering196.
     [Google Scholar]
  22. Farhadi, H., S.Ayatollahi and M.Fatemi (2021). “The effect of brine salinity and oil components on dynamic IFT behavior of oil-brine during low salinity water flooding: Diffusion coefficient, EDL establishment time, and IFT reduction rate.” Journal of Petroleum Science and Engineering196: 107862.
     [Google Scholar]
  23. Farhadi, H., S.Mahmoodpour, S.Ayatollahi and M.Fatemi (2023). “A novel oil/brine surface complexation model: Capturing the dynamic nature of the interface using IFT.” Journal of Molecular Liquids391.
     [Google Scholar]
  24. Farzaneh, S., M.Sohrabi, J.Mills, P.Mahzari and K.Ahmed (2015). Oil Recovery Improvement from Low Salinity Waterflooding in a Clay-free Silica Core. IOR 2015–18th European Symposium on Improved Oil Recovery.
     [Google Scholar]
  25. Farzaneh, S. A., A.Carnegie, M.Sohrabi, J. R.Mills, J. M.Facanha and B.Sellers (2017). A case study of oil recovery improvement by low salinity water injection. Abu Dhabi International Petroleum Exhibition and Conference, SPE.
     [Google Scholar]
  26. Gingerich, S. B., C. I.Voss and A. G.Johnson (2017). “Seawater-flooding events and impact on freshwater lenses of low-lying islands: Controlling factors, basic management and mitigation.” Journal of Hydrology551: 676–688.
     [Google Scholar]
  27. Gong, L., L.Zhang, L.Xiang, J.Zhang, V.Fattahpour, M.Mamoudi, M.Roostaei, B.Fermaniuk, J.-L.Luo and H.Zeng (2020). “Surface Interactions between Water-in-Oil Emulsions with Asphaltenes and Electroless Nickel-Phosphorus Coating.” Langmuir.
     [Google Scholar]
  28. Hajirezaie, S., X.Wu and C. A.Peters (2017). “Scale formation in porous media and its impact on reservoir performance during water flooding.” Journal of Natural Gas Science and Engineering39: 188–202.
     [Google Scholar]
  29. Hamouda, A. A. and N.Bagalkot (2019). “Effect of salts on interfacial tension and CO2 mass transfer in carbonated water injection.” Energies12(4): 748.
     [Google Scholar]
  30. Hoggart, S., M.Hanley, D.Parker, D.Simmonds, D.Bilton, M. Filipova-Marinova, E.Franklin, I.Kotsev, E.Penning-Rowsell and S.Rundle (2014). “The consequences of doing nothing: The effects of seawater flooding on coastal zones.” Coastal Engineering87: 169–182.
     [Google Scholar]
  31. Høgnesen, E., S.Strand and T.Austad (2005). Waterflooding of preferential oil-wet carbonates: Oil recovery related to reservoir temperature and brine composition. SPE Europec featured at EAGE Conference and Exhibition?, SPE.
     [Google Scholar]
  32. Huang, C, M.Cui, Z.Sun, F.Liu, B. A.Helms and T. P.Russell (2017). “Self-regulated nanoparticle assembly at liquid/liquid interfaces: A route to adaptive structuring of liquids.” Langmuir33(32): 7994–8001.
     [Google Scholar]
  33. Ikeda, N, M.Aratono and K.Motomura (1992). “Thermodynamic study on the adsorption of sodium chloride at the water/hexane interface.” Journal of colloid and interface science149(1): 208–215.
     [Google Scholar]
  34. Jian, C., M. R.Poopari, Q.Liu, N.Zerpa, H.Zeng and T.Tang (2016). “Mechanistic Understanding of the Effect of Temperature and Salinity on the Water/Toluene Interfacial Tension.” Energy & Fuels30(12): 10228–10235.
     [Google Scholar]
  35. Kazemzadeh, Y., I.Ismail, H.Rezvani, M.Sharifi and M.Riazi (2019). “Experimental investigation of stability of water in oil emulsions at reservoir conditions: Effect of ion type, ion concentration, and system pressure.” Fuel243: 15–27.
     [Google Scholar]
  36. Keradeh, M. P. and S. A.Tabatabaei-Nezhad (2024). “Enhanced oil recovery and mitigating challenges in sandstone oil reservoirs employing EDTA chelating agent/seawater flooding.” Results in Engineering23: 102733.
     [Google Scholar]
  37. Khajepour, H, M.Mahmoodi, D.Biria and S.Ayatollahi (2014). “Investigation of wettability alteration through relative permeability measurement during MEOR process: A micromodel study.” Journal of Petroleum Science and Engineering120: 10–17.
     [Google Scholar]
  38. Li, X., X. a. Yue, Z.Wang, R.Yan and Y.Guo (2021). “Role of Emulsification and Interfacial Tension of a Surfactant for Oil Film Displacement.” Energy & Fuels35(4): 3032–3041.
     [Google Scholar]
  39. LIMA, M. (2016). Efeito do ion sulfate nainjeção de aguade salinidade projetada em carbonatos. 2016, Dissertação (Mestrado em Engenharia de Petró1eo)-Faculdade de Engenharia. ...
     [Google Scholar]
  40. Mahmoodi, A., S.Hosseinzadehsadati, H.Kermani and H.Nick (2023). “On the benefits of desulfated seawater flooding in mature hydrocarbon fields.” Science of the Total Environment904: 166732.
     [Google Scholar]
  41. Mahzari, P. and M.Sohrabi (2014). Crude oil/brine interactions and spontaneous formation of micro-dispersions in low salinity water injection. SPE improved oil recovery symposium, Society of Petroleum Engineers.
     [Google Scholar]
  42. Mahzari, P. and M.Sohrabi (2015). Impact of Micro-Dispersion Formation on Effectiveness of Low Salinity Waterflooding. IOR 2015–18th European Symposium on Improved Oil Recovery.
     [Google Scholar]
  43. Mahzari, P., M.Sohrabi, A. J.Cooke and A.Carnegie (2018). “Direct pore-scale visualization of interactions between different crude oils and low salinity brine.” Journal of Petroleum Science and Engineering166: 73–84.
     [Google Scholar]
  44. Mahzari, P., M.Sohrabi and J. M.Façanha (2019). “The decisive role of microdispersion formation in improved oil recovery by low-salinity-water injection in sandstone formations.” SPE Journal24(06): 2859–2873.
     [Google Scholar]
  45. McGuire, P., J.Chatham, F.Paskvan, D.Sommer and F.Carini (2005). Low salinity oil recovery: An exciting new EOR opportunity for Alaska's North Slope. SPE western regional meeting, SPE.
     [Google Scholar]
  46. Mehraban, M. F., S. A.Farzaneh and M.Sohrabi (2021). “Debunking the impact of salinity on crude oil/water interfacial tension.” Energy & Fuels35(5): 3766–3779.
     [Google Scholar]
  47. Merdhah, A. B. B. and A. A. M.Yassin (2007). “Scale formation in oil reservoir during water injection at high-salinity formation water.” Journal of applied sciences7(21): 3198–3207.
     [Google Scholar]
  48. Owens, W. and D.Archer (1971). “The effect of rock wettability on oil-water relative permeability relationships.” Journal of Petroleum Technology23(07): 873–878.
     [Google Scholar]
  49. Puntervold, T., S.Strand and T.Austad (2009). “Coinjection of seawater and produced water to improve oil recovery from fractured North Sea chalk oil reservoirs.” Energy & fuels23(5): 2527–2536.
     [Google Scholar]
  50. Rahimi, A., B.Honarvar and M.Safari (2020). “The role of salinity and aging time on carbonate reservoir in low salinity seawater and smart seawater flooding.” Journal of Petroleum Science and Engineering187: 106739.
     [Google Scholar]
  51. Rane, J. P., D.Harbottle, V.Pauchard, A.Couzis and S.Banerjee (2012). “Adsorption kinetics of asphaltenes at the oil-water interface and nanoaggregation in the bulk.” Langmuir28(26): 9986–9995.
     [Google Scholar]
  52. Schechter, D., D.Zhou and F.Orr, Jr. (1991). Capillary imbibition and gravity segregation in low IFT systems. SPE Annual Technical Conference and Exhibition?, SPE.
     [Google Scholar]
  53. Schechter, D., D.Zhou and F.Orr, Jr. (1994). “Low IFT drainage and imbibition.” Journal of Petroleum science and Engineering11(4): 283–300.
     [Google Scholar]
  54. Schmitt, M., R.Toor, R.Denoyel and M. 1. Antoni (2017). “Spontaneous Microstructure Formation at Water/Paraffin Oil Interfaces.” Langmuir33(49): 14011–14019.
     [Google Scholar]
  55. Serrano-Saldaña, E., A.Domínguez-Ortiz, H.Pérez-Aguilar, I.Kornhauser-Strauss and F.Rojas-González (2004). “Wettability of solid/brine/n-dodecane systems: experimental study of the effects of ionic strength and surfactant concentration.” Colloids and Surfaces A: Physicochemical and Engineering Aspects241(1–3): 343–349.
     [Google Scholar]
  56. Shariatpanahi, S. F., S.Strand and T.Austad (2011). “Initial wetting properties of carbonate oil reservoirs: effect of the temperature and presence of sulfate in formation water.” Energy & fuels25(7): 3021–3028.
     [Google Scholar]
  57. Sohrabi, M., P.Mahzari, S. A.Farzaneh, J. R.Mills, P.Tsolis and S.Ireland (2017). “Novel insights into mechanisms of oil recovery by use of low-salinity-water injection.” SPE Journal22(02): 407–416.
     [Google Scholar]
  58. Stauffer, C. E. (1965). “The measurement of surface tension by the pendant drop technique.” The journal of physical chemistry69(6): 1933–1938.
     [Google Scholar]
  59. Strand, S., T.Puntervold and T.Austad (2008). “Effect of temperature on enhanced oil recovery from mixed-wet chalk cores by spontaneous imbibition and forced displacement using seawater.” Energy & Fuels22(5): 3222–3225.
     [Google Scholar]
  60. Strand, S., T.Puntervold and T.Austad (2016). “Water based EOR from clastic oil reservoirs by wettability alteration: A review of chemical aspects.” Journal of Petroleum Science and Engineering146: 1079–1091.
     [Google Scholar]
  61. Tao, J., C.Dai, W.Kang, G.Zhao, Y.Liu, J.Fang, M.Gao and Q.You (2017). “Experimental Study on Low Interfacial Tension Foam for Enhanced Oil Recovery in High-Temperature and High-Salinity Reservoirs.” Energy & Fuels31(12): 13416–13426.
     [Google Scholar]
  62. Wang, F. (1988). “Effect of wettability alteration on water/oil relative permeability, dispersion, and flowable saturation in porous media.” SPE reservoir engineering3(02): 617–628.
     [Google Scholar]
  63. Wang, Y., X.Li and J.Lu (2021). “Experimental study of natural ions and rock interactions for seawater breakthrough percentage monitoring during offshore seawater flooding.” SPE Journal26(06): 3949–3969.
     [Google Scholar]
  64. Zhang, P. and T.Austad (2006). “Wettability and oil recovery from carbonates: Effects of temperature and potential determining ions.” Colloids and Surfaces A: Physicochemical and Engineering Aspects279(1–3): 179–187.
     [Google Scholar]
  65. Zhang, P., M. T.Tweheyo and T.Austad (2006). “Wettability alteration and improved oil recovery in chalk: The effect of calcium in the presence of sulfate.” Energy & fuels20(5): 2056–2062.
     [Google Scholar]
  66. Zhang, P., M. T.Tweheyo and T.Austad (2007). “Wettability alteration and improved oil recovery by spontaneous imbibition of seawater into chalk: Impact of the potential determining ions Ca2+, Mg2+, and SO42−.” Colloids and Surfaces A: Physicochemical and Engineering Aspects301(1–3): 199–208.
     [Google Scholar]
/content/papers/10.3997/2214-4609.202531059
Loading
Experimental Investigation of Seawater Injection for Enhanced Oil Recovery
Conference Proceedings 2025, 1 (2025); https://doi.org/10.3997/2214-4609.202531059
/content/papers/10.3997/2214-4609.202531059
/content/papers/10.3997/2214-4609.202531059
Loading

Data & Media loading...

Most Cited This Month Most Cited RSS feed

This is a required field
Please enter a valid email address
Approval was a Success
Invalid data
An Error Occurred
Approval was partially successful, following selected items could not be processed due to error